Volkswagen Passat Forum banner

2002 Passat B5.5 AZM Engine vibrates after all mountings replacments :(

2.3K views 4 replies 3 participants last post by  rashidjafar  
#1 ·
Hi guys,

I replaced all mountings (Snub,2 Engine,rest gear mountings) 2 months back. And i am not satisfied much because my headlights still vibrates at idle and stop lights. Even some plastic inside cabin vibrates :(
I usually feel the most vibration when i cold starts. At first its little vibration which increase as rpm goes down till 800rpm.
Vibration is reduced little when i switch on a/c and also During driving vibration is very less and cant be felt much.

What i felt is that engine just vibrate at idle on its own.
Where should i start and suspect ?

2002 Passat B5.5
AZM Engine , 150000kms.
Timing belt replaced at 90,000 kms.
New tyres and both wheel alignment and Wheel balance done 2 months back.

Thanks and Regards,
Rashid Jafar
 
#4 ·
Yes Zach. I installed the snub mount by accelarating few times And then i torqued the bolts.

But even today i felt more vibration at a stage where my rpm came 800 from a cold start.
Feels like small wobbling due lack of something :(