Volkswagen Passat Forum banner
bpy
1-20 of 33 Results
  1. B6 Garage
    New to Passat World (and car mechanics in general)! I’m thinking of cleaning and refurbishing my turbo because I bought the car used and have no idea what the maintenance record is like. It seems to be in decent shape mechanically even with 190,000 miles on it. It’s a 2008 B6 2.0 BPY Wagon. I’m...
  2. Volkswagen Passat B6 Discussion
    Hello, I am new here but have been in the VW world forever. From modded 16v Sciroccos to VR6 Gti. Now I have a 2008 Passat, and a 2007 GTI both bpy engines and a 2004 Jetta 1.8t. Basically a lifetime VW owner. So...... this Passat has been giving me headaches it did something similar when I...
  3. New Member Introductions
    I recently bought this car with a broken timing belt, bent valves and so forth. I have done literally hundreds of broken belts in my life but after this one some weird issues started popping up. I have VCDS Hex Net so I ran a scan but no codes. It was pinging on load and it has the bpy oil...
  4. Volkswagen Passat B6 Discussion
    I have 2 codes that might be related (from other posters/forums): 008328 - Bank 1 Camshaft A (Intake) Position Actuator P2088 - 002 - Short to Ground 001681 - Fan 1 Control Circuit P0691 - 002 - Short to GND I need the wiring diagrams (2006 Passat 2.0T auto FWD, BPY engine) for both...
  5. Volkswagen Passat B6 Discussion
    After carbon cleaning of intake valves, and some other work, car run great for several warm ups. Then longer test drive, and started to idle rough, misfires on cylinder 4 and blowing noise that I can't pinpoint/locate. Starter fluid spraying revealed no leaks. Coil and plug swap no change...
  6. Volkswagen Passat B6 Discussion
    Can't find instructions to change the air bag module. Can someone post up DIY links? Does the center console, radio have to come out?
  7. Volkswagen Passat B6 Discussion
    I have rough idle and air leak code. By spraying carb clean, I found the rear passenger side large vent hose leaking (transitions into corrugated metal pipe). I tried to seat better, and put good hose clamp on, but still hissing. I had 'smoked' the car (leak test), very tight, no leaks. But...
  8. Volkswagen Passat B6 Discussion
    What measuring blocks does VAGcom VCDS provide for checking/verifying the timing on the BPY engine? for the old 1.8T and 2.7T, I used blocks 090-093. I would assume similar data is available for the 2.0T? What ARE the values/ranges to correct timing of the BPY engine?
  9. Volkswagen Passat B6 Discussion
    Hello everyone , so my passat b6 bpy engined failed , so i decided to embark in a project on rebuilding the engine, but honestly it was to costly, what i ended up doing got a 08 audi with a bwt engine on it . anyhow with the help of some mechanics, we swapped the engine and bolted right in...
  10. Volkswagen Passat B6 Discussion
    So we are now in court. Although I brought the car into a dealership in 2016 after getting a 2293 code. Calling VMoA they stated the codes have an extended warranty on certain part. Bring it to a dealer. At the dealer only 2 options given to us were. If its not under warranty, youll have to...
  11. Volkswagen Passat B6 Discussion
    I'm pretty sure my oil leak is coming from the part that my oil filter canister screws into. The filter canister is not wet itself, it's coming from behind that, and dripping on the black coolant pump directly in front of the engine. The leak is not a gusher, just enough to drip a few drops on...
  12. B6 Garage
    So if you had your entire car taken apart all the way to fix piston rings and come out with a noticeable gain in HP from this mess. (Maybe a Stage 2+ APR Tune) Your vehicle and info is: 2006 Passat B6 2.0T FSI / TFSI 16V DOHC 118,000 miles No damage done to block or head or camshafts Your...
  13. Volkswagen Passat B6 Discussion
    Returned from a 200+ mile trip yday afternoon, parked the car and this morning it failed to start. So far done the following Got it scanned, no engine related codes, only ones that show up are for outside mirror heating element and radio Checked battery, voltage is fine. Cant start even with a...
  14. Volkswagen Passat B6 Discussion
    So I put an 08 BPY in place of my bad 06 BPY. Everything matched up perfectly. I used my original harness and had to switch the oil sender from 2 prong to the 1 prong that came on mine. Got done and built oil pressure, the it started right up. Ran good for a few seconds then started to surge and...
  15. Volkswagen Passat B6 Discussion
    I have an 06 Passat with a BPY that is bad, the usual fuel pump failure, I bought it this way. I have searched here but cant find any confirmation that an 08 engine will work. I called the dealer and he said NO. Can anyone confirm this for me? And why not? Thanks in advance for any help!
  16. Volkswagen Passat B6 Discussion
    Let me start by saying hello to all and thank you ahead of time for you input and wisdom. My Passat has 117000 and I am starting to have a shudder at highway speeds ( 60-75 mph ) when I need to downshift to pass .. however there is no issue reaching these speeds or harsh shifts if the...
  17. New Member Introductions
    Let me start by saying hello to all and thank you ahead of time for you input and wisdom. My Passat has 117000 and I am starting to have a shutter at highway speeds ( 60-75 mph ) when I need to downshift to pass .. however there is no issue reaching these speeds or harsh shifts if the...
  18. Volkswagen Passat B6 Discussion
    06 78k miles 2.0t So when i got this car it needed work, put in valve cover gasket, vacuum pump and gasket and a autozone pvc. Then the car was driven less 500 miles. Then had to do a thermostat. When i disconnected the battery it ruined the power assisted rack. So i had someone put in a used...
  19. Parts For Sale
    I have a 97k miles 2.0t FSI BPY cylinder head w/ all the valves, springs and rockers for sale if anyone is interested. This can be interchanged with a BWT 2.0t FSI engine as well Great for sending to APR or IE to get ported for big turbo projects without having to first take your car apart...
  20. Volkswagen Passat B6 Discussion
    In search of a perfect running BPY for my B6 Passat. My engine had oil starvation causing the cam chain tensioner to break and ruin the whole engine. looking for an engine with lower miles..(under 100k) please let me know what you have or if I should attempt a rebuild.
1-20 of 33 Results
Top